DENG Gui-sheng，REN Tie-gang

(College of Chemistry and Chemical Engineering，Hunan Normal University，Changsha 410081，China)

Acetalization of Carbonyl Compounds with Diols Catalyzed by InCl3·4H2O

DENG Gui-sheng*，REN Tie-gang

(College of Chemistry and Chemical Engineering，Hunan Normal University，Changsha 410081，China)

Acetalization of aromatic and aliphatic aldehydes with diols catalyzed by InCl3·4H2O was carried out in refluxing benzene to give the corresponding acetals in 76%～85%yields.And ketone acetals were obtained in 75%～82%yields in the same method.

acetalization;diols;carbonyl compounds;indium trichloride

Acetals play an important role in synthetic carbohydrates［1］and steroid chemistry.In pharmaceutical，phytopharmaceutical，fragrance and lacquer industries，acetals are used both as intermediates and as end products［2-3］.Meanwhile，acetalization of carbonyl compounds as a method for protection of carbonyl group has been widely used in organic synthesis.There are many available methods reported in literatures.Among them，most involved the removal of water under acid-catalyzed condition［4］.Various catalysts have been used in the process，such as organic acid(sulfamic acid［5］)，solid acid［6］，acidic ionic liquid［7-8］，heteropolyacid［9］，Lewis acid(InF［10］，GaCl3［11］， NbCl3［12］)，cation-exchanged montmorillonite［13］，Rh(Ⅲ)triphos moieties［14］，TMSCl［15］，bis-trimethylsilyl ether of ethane-1，2-diols and trimethylsilyl triflate［16］，etc.Acetalization catalyzed by cadmium iodide under microwave irradiation has also been reported［17］.

Some reported methods are limited because of use of corrosives，effluent pollution or sensitivity to water，etc.Lewis acid-catalyzed acetalization is of current interest owing to its activity and stability.In particular，InCl3has been widely applied in various catalytic reactions because of operational simplicity and inertness to water.For example，InCl3-Me3SiCl-promoted Mukaiyama aldol reaction［18-20］，Knoevenagel condensation and the addition of allylic stannanes to aldehydes［21］，cross-aldol condensation［22］and diacetalization of 2，2-bis(hydroxymethyl)-1，3-propanediol［23］have been disclosed.On the basis of the consideration，we tried to exploit InCl3-catalyzed acetalization of carbonyl compounds with diols.

In our procedure，the reaction of carbonyl compounds with diols was carried out in the presence of InCl3·4H2O.The commercially available benzaldehyde 1a and 1，2-ethandiol 2a were first used as a model to screen appropriate solvents.The results are summarized in Table 1.As expected，2-phenyl-1，3-dioxolane 3a was generated in various refluxing solvents.Yields were high in refluxing benzene，toluene，cyclohexane and THF，however，low in refluxing DMF and dichloromethane.Benzene was the best solvent based on the yield.

Table 1 Solvent effect on yieldof the reaction of benzaldehyde 1a with 1，2-ethandiol 2a*

Representative carbonyl compounds 1 and diols 2 submitted to the above optimal conditions.The results were summarized in Table 2.The acetalization of aromatic or aliphatic aldehydes and aliphatic ketone with 1，2-ethandiol 2a and 1，2-propandiol 2b gave the corresponding acetals in good to excellent yield(entries 3a-3i in Table 2).In the case of 1，3-propandiol 2c，similar results were obtained(entries 3j-3m in Table 2).In comparison with aromatic or aliphatic aldehydes，the reaction of aliphatic ketone with diols gave the corresponding acetals in lower yields，and but for longer reaction time(entries 3g，3i and 3m in Table 2).

Table 2 Acetalization of carbonyl compounds with diols catalyzed by InCl3·4H2O*

In summary，an efficient and facile method for InCl3-catalyzed synthesis of the acetals via reaction of carbonyl compounds with diols has been demonstrated in this paper.InCl3is a mild catalyst，not sensitive to water and commercially available.This new method has several advantages，such as mild reaction conditions，high yields，simple operation，high reaction efficiency and adaptability to aromatic，aliphatic aldehydes and ketones.

Experimental Section

1H NMR spectra were recorded on Varian Mercury 200 spectrometer in CDCl3solution using tetramethylsilane(TMS)as the internal standard.IR spectra were recorded on a Nicolet instrument corporation's IR-510P spectrometer.

Typical procedure for acetalization of carbonyl compounds with diols catalyzed by InCl3·4H2O.A mixture of benzaldehyde(2.12 g，20 mmol)，1，2-ethandiol(1.24 g，20 mmol)and InCl3·4H2O(0.058 g，2 mmol)in benzene(15 mL)was stirred at reflux for 2 h，using a Dean-Stark apparatus for removal of water.The reaction was monitored by TLC.After cooling，the combined organic layer was concentrated.The residue was distilled in vacuum to afford acetal 3a(2.56 g，83%yield).

［1］CHéRY F，CABIANCA E，TATIBOU?T A，et al.Carbohydrate-derived PSE acetals:controlled base-induced ring cleavage［J］.Tetrahedron，2012，68(2):544-551.

［2］ABEND A M，CHUNG L，BIBART R T，et al.Concerning the stability of benzyl alcohol:formation of benzaldehyde dibenzyl acetal under aerobic conditions［J］.J Pharm Biomed Anal，2004，34(5):957-962.

［3］GENT P A.The allyl ether as a protecting group in carbohydrate chemistry.PartⅣ.The 2-methylallyl ether group［J］.J Chem Soc Perkin Trans 1，1973:1858-1863.

［4］SMITH III A B，F(xiàn)UKUI M，VACCARB H A，et al.Phyllanthoside-phyllanthostatin synthetic studies.7.Total synthesis of(+)-phyllanthocin and(+)-phyllanthocindiol［J］.J Am Chem Soc，1991，113(6):2071-2092.

［5］WANG B，GU Y，SONG G，et al.An efficient procedure for protection of carbonyls catalyzed by sulfamic acid［J］.J Mol Cat A:Chem，2005，233(1-2):121-126.

［6］LIU L，ZHAO Y，GAN S，et al.Acetalization of carbonyl compounds with 2，2，4-trimethyl-1，3-pentanediol catalyzed by novel carbon based solid acid catalyst［J］.J Nat Gas Chem，2008，17(2):149-152.

［7］MIAO J，WAN H，SHAO Y，et al.Acetalization of carbonyl compounds catalyzed by acidic ionic liquid immobilized on silica gel［J］.J Mol Cat A:Chem，2011，348(1):77-82.

［8］DUAN Z，GU Y，DENG Y.Green and moisture-stable Lewis acidic ionic liquids(choline chloride·xZnCl2)catalyzed protection of carbonyls at room temperature under solvent-free conditions［J］.Catal Commun，2006，7(9):651-656.

［9］JERMY B R，PANDURANGAN A.H3PW12O40supported on MCM-41 molecular sieves:An effective catalyst for acetal formation.Appl Catal A:General，2005，295(2):185-192.

1.1 單純自體脂肪注射隆乳 小乳癥患者采用自體脂肪注射進行隆乳可以獲得較為自然的外觀及手感，因此該項技術尤其適用于對假體隆乳有排斥的求美者。至2011年，僅在禁令解除后的第2年，國際整形外科醫師協會(International Society of Aesthetic Plastic Surgery,ISAPS)統計[4]，當年美國自體脂肪隆乳的比例已經占到乳房整形手術的20%。

［10］MADABHUSHI S，MALLU K K R，CHINTHALA N，et al.Efficient and chemoselective acetalization and thioacetalization of carbonyls and subsequent deprotection using InF3as a reusable catalyst［J］.Tetrahedron Lett，2012，53(6):697-701.

［11］BAO Q，QIAO K，TOMIDA D，et al.Acetalization of carbonyl compounds catalyzed by GaCl3immobilized on imidazoliumstyrene copolymers［J］.Catal Commun，2009，10(12):1625-1628.

［12］SZYMONIAK J，BESAN?ON J，MO?SE C.Tandem carbonyl coupling-rearrangements promoted by the niobium(Ⅲ)reagent.Dual reductive and Lewis acid properties of NbCl3(DME)［J］.Tetrahedron，1992，48(19):3867-3876.

［13］THOMAS B，RAMU V G，GOPINATH S，et al.Catalytic acetalization of carbonyl compounds over cation(Ce3+，F(xiàn)e3+and Al3+)exchanged montmorillonites and Ce3+-exchanged Y zeolites［J］.Appl Clay Sci，2011，53(2):227-235.

［14］OTT J，TOMOBO G M R，SCHMID B，et al.A versatile rhodium catalyst for acetalization reactions under mild conditions［J］.Tetrahedron Lett，1989，30(45):6151-6154.

［15］CHAN T H，BRODS U A，CHALY T.A simple procedure for the acetalization of carbonyl compounds［J］.Synthesis，1983(3):203-205.

［16］LILLE M，AVERY M A.The protection of ketones and aldehydes as 4-trimethylsilylmethyl-1，3-dioxolanes［J］.Tetrahedron Lett，1994，35(7):969-972.

［17］LAKAR D D，PRAJAPATI D，SANDHU J S.Cadmium iodide catalyzed and efficient synthesis of acetals under microwave irradiations［J］.Chem Lett，1999，332(8):1283-1284.

［18］MARSHALL J A，HINKLE K W.Stereoselective SE2'additions of enantioenriched allylic tin and indium reagents to protected threose and erythrose aldehydes:a general strategy for the stereocontrolled synthesis of precursors to the eight diastereomeric hexoses and their enantiomers［J］.J Org Chem，1996，61(1):105-108.

［19］MARSHALL J A，HINKLE K W.Synthesis of anti-homoallylic alcohols and monoprotected 1，2-diols through InCl3-promoted addition of allylic stannanes to aldehydes［J］.J Org Chem，1995，60(7):1920-1921.

［20］MARSHALL J A，GAROFALO A W.Synthesis of chiral α，δ-dioxygenated allylic stannanes as reagents for carbohydrate synthesis and homologation［J］.J Org Chem，1996，61(25):8732-8738.

［21］JONES G.Organic reaction［M］.Wiley:New York，1967:204.

［22］DENG G，REN T.Indium trichloride catalyses aldol-condensations of aldehydes and ketones［J］.Synth Commun，2003，33(17):2995-3001.

［23］DENG G，REN T.Efficient procedure for synthesis of diacetals from InCl3·4H2O catalyzed reaction of 2，2 bis-hydroxymethyl-1，3-propanediol with aldehydes or ketones［J］.J Chem Res(S)，2003(1):24-25.

［24］HESSE G，F(xiàn)?RDERREUTHER M.Notizüber die verwendung von glykolsulfit zur herstellung von ?thylenketalen［J］.Chem Ber，1960，93(5):1249-1251.

［25］KANTLEHNER W，GUTBROD H-D.Acetalisierungen mit N，N-dimethylformamid-dimethylsulfat-addukt;darstellung von 1，3-dioxolanen und 1，3-dioxanen［J］.Liebigs Ann Chem，1979(9):1362-1369.

O621.3

A

1000-2537(2012)04-0035-05

四水合三氯化銦催化羰基化合物與二元醇的縮醛反應

鄧桂勝*，任鐵鋼

(湖南師范大學化學化工學院，中國長沙 410081)

在四水合三氯化銦催化下，于苯中加熱回流，脂肪及芳香醛與二元醇的縮醛反應形成相應的縮醛，產率76% ～85%.用同樣方法，能夠獲得縮酮，產率達75% ～82%.

縮醛反應;二元醇;羰基化合物;三氯化銦

2012-05-14

湖南省教育廳科研基金資助項目(03C247)

*

，E-mail:gsdeng@hunnu.edu.cn

(編輯 楊春明)