亚洲免费av电影一区二区三区,日韩爱爱视频,51精品视频一区二区三区,91视频爱爱,日韩欧美在线播放视频,中文字幕少妇AV,亚洲电影中文字幕,久久久久亚洲av成人网址,久久综合视频网站,国产在线不卡免费播放

        ?

        跨臨界CO2氣冷器耗散分析

        2015-06-15 19:16:10石冬冬馬逸平陳文景
        制冷學報 2015年6期
        關鍵詞:上海理工大學換熱器系數

        石冬冬 呂 靜 曹 科 馬逸平 陳文景 李 昶

        (上海理工大學環境與建筑學院 上海 200093)

        石冬冬 呂 靜 曹 科 馬逸平 陳文景 李 昶

        (上海理工大學環境與建筑學院 上海 200093)

        1 數學模型

        以文獻[12]中的CO2套管式氣冷器為研究對象,如圖1所示,管內側為跨臨界CO2制冷劑,管外側為冷卻水,該氣冷器采用逆流的方式進行熱交換。

        圖1 CO2氣冷器示意圖Fig.1 Schematic diagram of CO2 gas cooler

        (1)

        當定壓比熱為常數時,由式(1)可得:

        (2)

        圖2所示為CO2在跨臨界區不同壓力下定壓比熱隨溫度變化曲線。由圖2可知,當壓力一定時,CO2定壓比熱為溫度的函數,在臨界點附近達到最大值;當狀態點遠離臨界點時,其定壓比熱逐漸減??;在高溫段,CO2壓力越大,定壓比熱越大。

        圖2 不同壓力下CO2定壓比熱曲線圖Fig.2 The specific heat graphical chart of carbon dioxide at different pressure

        (3)

        化簡后得式(4):

        (4)

        圖3 CO2氣冷器微元?jiǎng)澐质疽鈭DFig.3 Infinitesimal division diagram of CO2 gas cooler

        整個換熱過程中,在臨界點附近,CO2定壓比熱隨溫度變化而大幅度變化,為提高計算準確性,沿水流動方向?qū)饫淦鞣譃榈乳L度的N個微元,如圖3所示。對于各個微元段,以CO2入口溫度及壓力來確定其所在微元段的各物性參數,以該微元段的換熱量及CO2進出口溫度差確定CO2的平均熱容流量。由此可得:

        (5)

        (6)

        (7)

        (8)

        (9)

        (10)

        ΔE*=(ΔE*)T+(ΔE*)p=(ΔEr*)T+(ΔEw*)T+(ΔE*)p

        (11)

        在換熱器設計時,一般冷熱流體的入口工況已知,未知參數為各微元段CO2與水進出口溫度Tri,j、Tro,j、Twi,j、Two,j、CO2壓降Δpr,j,以及氣冷器CO2與水出口溫度Tro、Two。

        1.2 氣冷器傳熱分析

        為了簡化計算模型,對每個微元段做如下假設:1)管子沿軸方向不存在熱傳導;2)忽略熱損失;3)忽略微元段CO2側壓降對物性參數的影響;4)CO2與水側均為一維穩態流動;5)忽略污垢形成的熱阻。

        以j微元段為例,該微元段可視為一個小的逆流換熱器,建立熱平衡方程,采用ε-NTU方法,計算得出該微元段CO2與水的出口溫度。

        1)水側熱平衡方程:

        Qw,j=mwcpw(Two,j-Twi,j)

        (12)

        2)CO2側熱平衡方程:

        (13)

        3)ε-NTU方法:

        Qj=εjCmin,j(Tri,j-Twi,j)

        (14)

        對于逆流換熱器,效能系數[14]的表達式為:

        (15)

        CO2側與水側的整體傳熱系數定義如下:

        (16)

        CO2側對流換熱系數采用Gnielinski V[15]提出的傳熱關聯式計算:

        (17)

        當Re<2300時,水側對流換熱系數采用Sieder-Tate[16]公式來計算:

        (18)

        此公式的定性溫度為流體的平均溫度,ηp為按照壁面溫度計算得到的動力粘滯系數。

        當Re≥2300時,水側對流換熱系數采用Dittus-Boelter[17]傳熱關聯式計算:

        Nuw=0.023Rew0.8Prw0.4

        (19)

        1.3 氣冷器壓降分析

        該氣冷器為平行流換熱器,其靜壓損失為0,總壓降由摩擦壓降、加速壓降與局部阻力壓降組成。以j微元段為例,計算該微元段總壓降。

        1)CO2側摩擦壓降由式(20)計算:

        (20)

        f為摩擦因子,采用Churchill關聯式[18]:

        (21)

        絕對粗糙度ψ取典型值5 μm。

        2)CO2側加速壓降[12]由式(22)計算:

        (22)

        3)CO2側局部阻力壓降[12]由式(23)計算:

        (23)

        1.4 仿真計算

        圖4 CO2氣冷器耗散計算仿真流程Fig.4 Simulation process of CO2 gas cooler entransy dissipation

        2 結果與討論

        2.1 模型驗證

        表1 文獻[12]實驗管型尺寸Tab.1 Geometrical dimensions of test tube[12]

        (24)

        圖5 CO2與水溫度沿程分布的實驗值與模擬值比較Fig.5 Comparisons of experimental and numerical simulation value of CO2 and water temperature distribution

        圖6 CO2側壓降實驗值與模擬值比較Fig.6 Comparisons of experimental and numerical simulation value of CO2 pressure drop

        2.2 算例分析

        (25)

        (26)

        圖7 當pr=9 MPa、mw=30 g/s、Tri=363 K、Twi=283 K時, 跨臨界CO2氣冷器耗散產生因素分析Fig.7 Analysis of transcritical CO2 gas cooler entransy dissipation generating factors when pr=9 MPa, mw=30 g/s, Tri=363 K,Twi=283 K

        圖8 當pr=11 MPa、Gr=300 kg/(m2·s)、mw=30 g/s、 Tri=363 K、Twi=283 K時,微元段耗散數分布Fig.8 Entransy dissipation number distribution of each infinitesimal segment when pr=11 MPa, Gr=300 kg/(m2·s),mw=30 g/s, Tri=363 K, Twi=283 K

        圖9 當pr=9 MPa、Tri=363 K、Twi=283 K時, CO2質量流率Gr、水質量流量mw對系統耗散數的影響Fig.9 The influence of CO2 and water mass flow rate on system entransy dissipation number when pr=9 MPa, Tri=363 K, Twi=283 K

        圖10 當Gr=300 kg/(m2·s)、Tri=363 K、Twi=283 K時, CO2進口壓力pr對系統耗散數的影響Fig.10 The influence of CO2 inlet pressure on system entransy dissipation number when Gr=300kg/(m2·s), Tri=363 K, Twi=283 K

        圖11 當Gr=300 kg/(m2·s)、pr=9 MPa、Twi=283 K時, CO2進口溫度對系統耗散數的影響Fig.11 The influence of CO2 inlet temperature on system entransy dissipation number when Gr=300 kg/(m2·s), pr=9 MPa, Twi=283 K

        圖12 當mw=30 g/s、pr=9 MPa、 Tri=363 K時水進口溫度對系統耗散數的影響Fig.12 The influence of water inlet temperature on system entransy dissipation number when mw=30 g/s, pr=9 MPa, Tri=363 K

        3 結論

        5)在確定熱力參數優化匹配時,應同時從CO2與水兩側入手,綜合考慮各參數間的相互影響,以達到更好的節能目的。

        本文受上海理工大學教育教學改革研究資助項目(2015-JPBKZ-005)和滬江基金資助項目(D14003)資助。(The project was supported by the Education Reform Project of USST(No.2015-JPBKZ-005) and the Hujiang Foundation of China(No.D14003).)

        符號說明

        A——傳熱面積,m2

        cp——比熱容,J/(kg·K)

        d——管徑,m

        G——質量流率,kg/(m2·s)

        h——焓值,kJ/kg

        l——微元段長度,m

        T——開爾文溫度,K

        m——質量流量,kg/s

        NTU——傳熱單元數

        p——壓力,MPa

        Pr——普朗克數

        Re——雷諾數

        Q——換熱量,W

        Qvh——熱容量,W

        T——溫度,K

        U——總換熱系數,W/(m2·K)

        ε——效能系數

        λ——導熱系數,W/(m2·K)

        η——?jiǎng)恿φ硿禂?shù),Pa·s

        ζ——局部阻力系數

        下標

        i——進口

        j——流程數

        o——出口

        r——CO2

        w——水

        [1] Bejan A. Entropy generation through heat and fluid flow[M]. New York: Wiley, 1982.

        [2] Bejan A. Advanced engineering thermodynamics[M]. New York: Wiley, 1988.

        [3] Hesselgreaves J E. Rationalisation of second law analysis of heat exchangers[J]. International Journal of Heat & Mass Transfer, 2000, 43(22):4189-4204.

        [5] 過增元, 程新廣, 夏再忠. 最小熱量傳遞勢容耗散原理及其在導熱優化中的應用[J]. 科學通報, 2003, 48(1): 21-25. (Guo Zengyuan, Cheng Xinguang, Xia Zaizhong. The principle of the minimum heat transfer potential capacity and its application in the optimization of heat conduction[J]. Chinese Science Bulletin, 2003, 48(1): 21-25.)

        [7] 李志信, 過增元. 對流傳熱優化的場協同理論[M]. 北京: 科學出版社, 2010.

        [12] 呂靜. 二氧化碳跨臨界循環及換熱特性的研究[D]. 天津: 天津大學, 2005.

        [14] 連之偉. 熱值交換原理與設備[M]. 2版. 北京: 中國建筑工業出版社, 2006: 194-196.

        [15] Gnielinski V. New equations for heat and mass transfer in turbulent pipe and channel flows[J]. International Chemical Engineering, 1976, 16(2): 359-368.

        [16] 楊世明, 陶文銓. 傳熱學[M]. 4版. 北京: 高等教育出版社, 2007: 250-252.

        [17] 黃冬平, 梁貞潛, 丁國良, 等. 基于模型的二氧化碳微通道氣體冷卻器性能分析[J]. 化工學報, 2002, 53(8): 832-836. (Huang Dongping, Liang Zhenqian, Ding Guoliang, et al. Modeling and performance analysis of carbon dioxide micro-channel gas cooler [J]. CIESC Journal, 2002, 53(8): 832-836.)

        [18] 金紀峰. 采用微通道換熱器的二氧化碳汽車空調系統研究[D]. 上海: 上海交通大學, 2010.

        About the corresponding author

        Lü Jing, female, doctor candidate, associate professor, School of Environment and Architecture, University of Shanghai for Science and Technology, +86 21-55270275, E-mail: Lvjing810@163.com. Research fields: heat transfer characteristics of supercritical carbon dioxide.

        Entransy Dissipation Analyses of Transcritical CO2Gas Cooler

        Shi Dongdong Lü Jing Cao Ke Ma Yiping Chen Wenjing Li Chang

        (School of Environment and Architecture, University of Shanghai for Science and Technology, Shanghai, 200093, China)

        Transcritical CO2system has become a hot topic in the field of heat pumps and air conditioning. In this paper, the CO2gas cooler was taken as a research subject. The system entransy dissipation was produced by the temperature difference of heat transfer and flow resistance of inside and outside fluid. A steady state distributed parameter model for the transcritical region of CO2gas cooler was established to solve entransy dissipation numberΔE*. The main reason of entransy dissipation number generation and its distribution were analyzed. Meanwhile, the effects of CO2and entrance parameters of water on the system entransy dissipation number were discussed. Results from the mathematic model showed that system entransy dissipation was mainly caused by temperature difference of heat transfer. The more the temperature difference, the bigger the entransy dissipation number. In each infinitesimal segment, the entransy dissipation number and the magnitude of CO2temperature dropwere in an inverse relationship. At the critical point, ΔEj*reached a maximum value. With the increase of mass flow rate and inlet pressure of CO2, the system entransy dissipation number became lager. While with the increase of water mass flow rate, the system entransy dissipation number decreased. Meanwhile, the higher the pressure, the smaller the decreased magnitude of entransy dissipation number. With the increasing of CO2inlet temperature, the entransy dissipation number decreased. The decreased degree of entransy dissipation number goes down with the increase of CO2inlet temperature. In addition, the inlet temperature of water has little impact on system entransy dissipation number.

        gas cooler;transcritical cycle;entransy dissipation number;numerical simulation;carbon dioxide

        2015年5月26日

        0253- 4339(2015) 06- 0090- 08

        10.3969/j.issn.0253- 4339.2015.06.090

        TB61+1;TQ051.5

        A

        呂靜,女,博士研究生,副教授,上海理工大學環境與建筑學院,(021)55270275,E-mail:Lvjing810@163.com。研究方向:超臨界二氧化碳傳熱特性的研究。

        猜你喜歡
        上海理工大學換熱器系數
        ASM-600油站換熱器的國產化改進
        能源工程(2021年3期)2021-08-05 07:26:14
        《上海理工大學學報》征稿簡則
        上海理工大學
        翅片管式換熱器的傳熱研究進展
        制冷(2019年2期)2019-12-09 08:10:36
        這些待定系數你能確定嗎?
        打雪仗
        過年啦
        兩張圖弄懂照明中的“系數”
        中國照明(2016年6期)2016-06-15 20:30:14
        310S全焊式板殼型換熱器的焊接
        焊接(2016年10期)2016-02-27 13:05:35
        大直徑重疊式浮頭式換熱器的制造
        低溫與特氣(2014年4期)2014-03-20 13:36:49
        无码精品国产一区二区三区免费| 久国产精品久久精品国产四虎 | 亚洲综合色自拍一区| 国产精品青草久久久久婷婷| 亚洲一区二区日韩在线| 日本一区二区三区免费精品| 亚洲成人色区| 中文亚洲爆乳av无码专区| 琪琪av一区二区三区| 又硬又粗进去好爽免费| 国产精品丝袜久久久久久不卡| 国产成人综合久久久久久| 国产丝袜在线福利观看| 亚洲午夜无码毛片av久久| 日本aⅴ大伊香蕉精品视频| 1精品啪国产在线观看免费牛牛| 92自拍视频爽啪在线观看| 国产女人18毛片水真多18精品| 国产精品美女久久久久| 日本理论片一区二区三区| 国产丝袜一区丝袜高跟美腿| 日日躁夜夜躁狠狠躁| 人人妻人人添人人爽日韩欧美| 中文字幕偷拍亚洲九色| 少妇免费av一区二区三区久久| 国产精品亚洲欧美大片在线看| 亚洲av无码片在线播放| 男女动态视频99精品| 久久精品中文字幕无码绿巨人| 少妇spa推油被扣高潮| 青青草视频在线视频播放| 国产麻豆久久av入口| 东北妇女肥胖bbwbbwbbw| 亚洲av在线播放观看| 国产精品,在线点播影院| 久久久天堂国产精品女人| 色橹橹欧美在线观看视频高清| 综合色天天久久| 少妇人妻无一区二区三区| 女的扒开尿口让男人桶30分钟| 国产在线成人精品|