周紅燕,陳 喆,2*,李侃麒,冷為貴,王宗抗

赤泥對堆肥腐熟度及其產品對稻米Cd阻控效果

周紅燕1,陳 喆1,2*,李侃麒1,冷為貴3,王宗抗3

(1.桂林理工大學環境科學與工程學院,廣西 桂林 541004；2.廣西師范大學,珍稀瀕危動植物生態與環境保護教育部重點實驗室,廣西 桂林 541004；3.貴港市芭田生態有限公司,廣西 貴港 537000)

以赤泥作為堆肥添加劑進行雞糞好氧堆肥試驗,分析了堆肥過程中赤泥對溫度、pH值、電導率(EC)及種子發芽指數(GI)的影響.通過三維熒光與紫外-可見光光譜特征解析堆肥過程中腐殖酸(HA)組分的演變特征.并利用盆栽實驗探索堆肥產品對礦區土壤中稻米鎘的阻隔效果.結果表明,赤泥的添加提高了堆體高溫期的溫度.EC較堆肥前均顯著降低,但赤泥堆肥EC(4.29mS/cm)顯著高于雞糞堆肥EC(3.59mS/cm).雞糞堆肥與赤泥堆肥的GI隨著堆肥時間的增長而升高,在堆肥結束時分別達到100.2%和96.44%,說明2種堆肥產品均未表現出植物毒性.2種堆肥HA中類蛋白質等物在堆肥過程中均轉化為較為穩定的類腐殖質物質,HA的SUVA254、SUVA280和A226～400在堆肥結束后也顯著提高,表明堆肥的腐殖化程度升高.此外,赤泥的添加提高了腐殖化參數數值,證明赤泥的加入能夠加速堆肥腐殖化進程.在盆栽實驗中,雞糞堆肥與赤泥堆肥均提高了土壤的pH值,降低了土壤中DTPA-Cd和糙米中Cd的含量.其中,施用2g/kg赤泥堆肥后,糙米Cd含量降低幅度最大,為58.68%,水稻糙米中Cd的含量由未施用堆肥的0.42mg/kg降低至0.17mg/kg.因此,赤泥的添加可以在一定程度上提高堆肥效率,同時施加堆肥產品對土壤Cd的生物有效性及水稻植株內Cd起到抑制與阻隔作用,且施加赤泥堆肥效果更為顯著.

赤泥；雞糞；堆肥；水稻；鎘污染；重金屬

赤泥是制鋁工業提取氧化鋁時排出的工業固體廢棄物,廣西平果鋁是中國特大型鋁土礦,年產氧化鋁高達200萬t,年排放赤泥量也高達約200萬t[1].鋁礦開采造成赤泥的露天隨意堆放不僅占用礦區大量耕地資源,而且雨水對赤泥堆場的不斷沖刷與淋溶作用已造成礦區大面積重金屬污染,其中以鎘(Cd)污染耕地超標問題尤為突出.目前,赤泥的主要利用途徑包括生產水泥、混凝土[2],提取有價金屬[3]等.研究表明,赤泥因其堿性可有效增加土壤pH值,有利于鐵錳氧化物的形成[4],能夠降低金屬的溶解度和生---物有效性.同時,由于赤泥中富含的鋁硅酸鹽可吸附或絡合重金屬[5],使得赤泥可被作為土壤鈍化劑[6]使用,但仍需通過預處理與無害化等手段確保赤泥投加的安全性.通過堆肥可將畜禽糞便中的病原體、抗生素和重金屬等物質無害化,使之成為優質的肥料[7].堆肥過程中通常添加秸稈、粉煤灰[8]和石灰[9]等作為膨脹劑和鈍化劑,加速堆肥發酵,鈍化重金屬,提升堆肥品質.土壤中施用有機肥不僅可以調節土壤養分含量和pH值,還可以固定、吸附土壤中的重金屬離子.Wang等[10]研究表明,施用有機-無機復混肥可以增加土壤pH值2～3個單位,并降低玉米植株各部位中Cd的濃度;Zhang等[11]的研究也表明,豬糞堆肥可以代替化肥施用于土壤,并能夠顯著降低小麥籽粒中重金屬鎳、銅、鋅、鎘和鉛的含量,且低于我國小麥食品標準限值.赤泥對土壤中的重金屬也可以起到較好的鈍化作用[12].

本研究以雞糞與米糠為基質,以赤泥為輔料進行雞糞好氧堆肥試驗,通過三維熒光和紫外-可見光光譜,分析堆肥腐殖酸中有機物質的變化,探究赤泥對堆肥效率與質量的影響;并對水稻進行盆栽實驗探索堆肥產品對礦區Cd污染土壤中水稻稻米Cd的阻隔效果,為利用赤泥提高堆肥效率與品質提供參考.

1 材料與方法

1.1 供試材料

堆肥實驗采用雞糞與米糠為原料,以赤泥為輔料.雞糞取自廣西桂林豐悅農業科技發展有限公司,米糠取自廣西賀州農豐寶公司,赤泥取自廣西平果鋁業公司.盆栽實驗供試土壤采自某礦區周邊Cd污染耕地土壤.堆肥原輔材料及供試土壤的基礎理化性質如表1所示.

表1 堆肥原輔料與供試土壤的基礎理化性質

1.2 堆肥實驗

1.2.1 實驗設計 堆肥發酵桶有效體積為50L,堆肥桶高為41cm,上口直徑為40cm,下口直徑為33cm,桶底鋪一層多面空心球,上覆雙層紗網.根據研究目的共設置2個處理,雞糞堆肥(CM):將雞糞:米糠以質量比5:1均勻混合;赤泥堆肥(RM):將雞糞:米糠:赤泥以質量比5:1:0.75均勻混合,每個處理設置3個重復.調節含水率和碳氮比分別為60%和25/1,采用強制通風好氧堆肥方式,使用氧氣泵由下部篩網向上通風供氧,通氣量為2L/min.

1.2.2 采樣與前處理 堆肥歷時約45d,分別在堆肥的第0,5,11,19,28,36,45d采集樣品各約600g,采用五點法[13]對堆體中心部位進行取樣,混合均勻后采用四分法[13]將樣品分為3份各200g,樣品于４℃冰箱保存,測定pH值、電導率(EC)、含水率及種子發芽指數(GI).一份樣品經－54℃凍干后研磨過100目篩,用于重金屬分析與腐殖質的提取實驗.另一份樣品保存于－20℃冰箱中.

1.2.3 基礎理化性質測定 每天早(08:00)、晚(18:00)分別對堆體進行溫度測定,從上到下依次測定5,15,25,35,40cm等5個層次的溫度,取其算術平均值為當天測量溫度,同時記錄環境溫度.取不同時期新鮮堆肥并按固液比1:10(/)加入超純水[14],150r/min混合振蕩浸提30min,取出并靜置30min,待測pH值.取不同時期新鮮堆肥樣品并按固液比1:10(/)加入超純水[14],混合振蕩浸提30min,取出在4000r/min,25℃條件下離心10min,待測電導率.

1.2.4 種子發芽指數(%) 取新鮮堆肥樣品并按固液比1:10(/)加入超純水,混合振蕩浸提30min,取出并靜置浸提1h,在4000r/min,25℃條件下離心10min后,用定性濾紙過濾,吸取10mL 濾液于墊有濾紙的培養皿內,均勻放入20粒小白菜種子(種子需先置于蒸餾水中浸泡2h,挑選飽滿種子),蓋上皿蓋,在25℃培養箱中避光培養72h后測定發芽率和根長[15].每個樣品3次重復,同時以去離子水做空白試驗.GI(%)=(處理種子發芽率′處理種子根長)/(對照種子發芽率′對照種子根長)′100%.

1.2.5 堆肥腐殖酸(HA)的提取 堆肥腐殖酸提取按照國際腐殖質協會提供的方法[16]進行提取.

1.2.6 HA三維熒光(3D-EEM)測定與分析[17]3D-EEM采用儀器Perkin Elmer Lumines-cence Spectrometer LS50B測定.激發光源:150W氙弧燈;PMT電壓:700V;信噪比>110;帶通(Bandpass):激發波長(x)＝10nm;發射波長(m)＝10nm;掃描速度:1200nm/min.激發發射波長范圍x:300～ 450nm,m:350～600nm.平行因子分析(PARAFAC)采用MATLAB7.11中DOMFluor工具包分析.

1.2.7 HA紫外-可見光光譜(UV-Vis)測定[18]UV-Vis采用UV-8000a光度計測定.以純水作為空白對照,在紫外吸收區,掃描波長范圍為190～ 700nm,掃描間距為1nm.首先將待測樣品的TOC調整為20mg/L以下,掃描全譜.

1.3 盆栽實驗

1.3.1 實驗設計 本實驗共設7個處理,不添加堆肥為對照(CK),施加純雞糞0.5,1和2g/kg風干土壤(CM0.5、CM1和CM2),施加赤泥堆肥0.5,1和2g/kg風干土壤(RM0.5、RM1和RM2).每個處理設3個重復.將15kg風干土裝入25L培養桶,桶高為30cm,上口直徑為32cm,下口直徑為29cm,在淹水狀態下(土面水深 3～4cm)平衡30d后移苗.本實驗采用的水稻品種均為陸兩優996(Lu Liang You996).每盆移栽4株水稻秧苗,移栽后90d(抽穗期)收獲.整個生育期保持土面水深3～4cm.實驗期間水稻無病蟲害發生.在移苗21d后施入堆肥.

1.3.2 采樣與預處理 水稻收獲后,將水稻籽粒脫殼,用不銹鋼粉碎機粉碎至約1mm的粉末,測定Cd的含量.水稻收獲后,采集培養桶中土樣,風干,混勻,過20目篩,測定有效態Cd的含量.

1.3.3 有效硅的測定[19]采用0.025mol/L檸檬酸緩浸提,進行鉬藍比色.

1.3.4 重金屬總量的測定[20]重金屬總量采用三酸(HNO3-HF-HClO4)消解法進行消解,使用ICP- OES待測(ICP-OES,Opetima 7000DV).

1.3.5 重金屬有效態的測定[21]稱取風干土壤樣品并按固液比1:10(/)加入DTPA溶液,在180r/min條件下室溫振蕩反應2h,然后在4000r/min,25℃條件下離心10min,過0.45μm濾膜,使用 ICP-OES待測.

1.4 數據統計與分析

數據統計分析用Microsoft Excel 2010以及SPSS11.5完成,用Duncan法進行顯著性多重比較分析,用Pearson系數法(<0.05)進行相關性分析.數據繪圖用Origin 8.0完成.

2 結果與討論

2.1 赤泥對雞糞堆體溫度、pH值、EC、GI的變化

如圖1a所示,堆肥初期溫度迅速升高,CM與RM這2個處理的溫度均在堆肥第1天達到50℃以上,維持5d,即已達到堆肥無害化衛生要求[22].其中,CM最高溫度平均達到62.1℃,RM最高溫度平均達到66.8℃,說明赤泥的添加可以顯著提高堆體在高溫期的溫度(<0.05),這可能是因為在堆肥過程中,赤泥的堿性避免了pH值的降低并為微生物提供了足夠的鈣,增強了微生物的代謝活性[23].

如圖1b所示,CM與RM處理的pH值均呈先上升后下降的趨勢,這與前人研究[24]結果一致.在堆肥結束時,CM與RM的pH值分別為8.14和8.27.由于微生物分解蛋白質類有機物,含氮物質在微生物作用下被分解并產生大量氨氮,在堆體內積累使 pH值上升.隨著堆肥的進行,堆體有機物分解并產生小分子有機酸,導致pH值下降[25].

如圖1c所示,在堆肥過程中,CM處理的EC從6.13mS/cm降到3.59mS/cm;RM處理由5.25mS/cm降到4.29mS/cm.2種堆肥的EC值在堆肥過程中均呈現先上升,再下降的趨勢.堆肥完成時,RM的EC值要顯著高于CM的EC值(<0.05),表明赤泥的添加會增加堆體的EC值[26].

如圖1d所示,在堆肥初期,2種堆肥處理的GI增長速率較慢.隨著堆肥時間延長,兩種處理堆肥過程中GI增長迅速.CM與RM堆肥的GI最終分別達到100.21%和96.44%,這可能是由于RM的EC值大于CM的所導致.堆肥完成時,CM與RM這2種堆肥的GI均超過80%,表明隨著堆肥的進行,堆肥產品均已完成無害化并達到腐熟,對植物的毒害作用逐漸減少,且赤泥的投加并未造成堆肥產品的植物毒性[27].

圖1 不同處理在堆肥過程中溫度、pH值、EC與GI的動態變化

CM:雞糞堆肥;RM:含赤泥的雞糞堆肥

2.2 赤泥對堆肥HA組分的平行因子分析

2.2.1 堆肥HA組分特征 如圖2所示,經過PARAFAC得出兩組HA的組分均主要有3種,分別為組分1(C1:x=395nm,m=480nm)、組分2(C2:x=380nm,m=420nm)和組分3(C3:x=285nm,m=340nm).HA的成分主要以C1和C2為主.C1和C2均屬于類腐殖質物質,C1反映了長波類腐殖酸物質,C2反映了類富里酸物質[28];C3則反映了類色氨酸類物質(類蛋白物質)[29].CM與RM堆肥HA的熒光組分與已報道的市政污泥堆肥的熒光物質組成相似[30].

2.2.2 不同分子量熒光組分演變規律 如圖3所示,CM處理中,堆肥初期的HA組分主要以C3為主,占比64.15%,隨著堆肥進行,C3含量逐漸減少,堆肥結束時C3為22.52%,C1的含量則從13.89%增長至35.84%,C2從21.10%增長至41.64%.RM處理中,堆肥初期HA組分也以C3為主,但顯著低于CM中C3含量(<0.05),僅為51.29%,隨著堆肥進行,C3含量逐漸下降至20.43%.C1的含量從22.90%增長為38.97%,C2從25.81%增長至40.60%,與CM結果相似.從以上3種組分的含量變化可以得知有機物的降解由難到易為C1>C2>C3,即最易降解的為類蛋白質物質,這可能是由于C3的成分及結構簡單,生物利用性較高導致.此外,由于類腐殖酸中含有大量的芳香基團,C1含量的增長說明HA中芳香官能團大量增長[31].而赤泥的添加導致初始C3含量減少,初始C1含量增加,說明赤泥不僅促進了不穩定C3含量的快速降低,還促進更穩定的C1含量增加,從而加速了堆體的解毒過程[32].然而,在該研究中進行PARAFAC分析的樣品僅為14個,存在一定的局限性,在后續研究中應使用更多的樣品數量進行PARAFAC分析以保證數據的代表性.

圖2 三維熒光平行因子分析解析出不同HA的3種組分

圖3 堆肥不同階段中HA組分百分含量變化

2.3 堆肥HA的紫外特征分析

2.3.1 SUVA254和SUVA280不飽和C=C鍵會引起有機質在254nm波長下的紫外吸收,SUVA254(=254′100/TOC)被認為與芳香族化合物的含量呈正比[33].如圖4a、b所示,CM與RM中HA的SUVA254初始值分別為0.76和1.65,堆肥結束時分別為2.50與2.32.SUVA254一直呈增長趨勢,說明HA的C=C含量在堆肥過程中逐漸增加,HA物質穩定化程度得到了提高.同樣,SUVA280(=280′100/TOC)也可以表征堆肥的腐殖化程度,在相同TOC濃度下,SUVA280值越大,表示堆肥過程中非腐殖物質向腐殖質轉化,堆肥產品的穩定程度越高[34].CM與RM中HA的SUVA280初始值分別為0.67和1.51,堆肥結束時分別為2.35與2.30,進一步說明HA腐殖化程度提高.

2.3.2253/203和226-400253/203(有機物分子在紫外-可見光光譜的253nm和203nm處的吸光度之比)與芳香環上取代基的種類和取代程度相關,當芳香環取代基的脂肪鏈增加,該值將減小,若芳香環中羰基、羧基、羥基等取代基增多時,該值便隨之增加[35].如圖4c、d所示,CM與RM中HA的253/203(=253/203)初始值分別為0.14和0.17,在堆肥結束時分別為0.27和0.24.在堆肥過程中,CM與RM的253/203總體呈上升趨勢,這是由于在堆肥前期,HA物質的耗氧反應劇烈,苯環取代基上的含氧基團相對含量快速升高,苯環上的脂肪鏈發生聚合反應轉化為羥基、羧基等[36].據報道[37],堆肥物質的苯環結構是體現堆肥穩定化程度重要指標,226～400nm吸收帶具有很強紫外吸收,與有機質中的多個共軛體系的苯環相關,CM與RM中HA的226-400(226～ 400nm吸收帶的區域積分)初始值分別為2.11和5.22,堆肥結束后分別為8.30和7.82.226～400呈上升趨勢,說明有機質的分子縮合程度增高,芳香化程度增高,HA物質的穩定程度提高,堆肥產品逐漸穩定.以上結果說明,由于赤泥的加入使得RM中各腐殖化參數初始值顯著高于CM的初始值(<0.05),以此加速腐殖化過程.

2.4 堆肥HA不同光譜特征參數相關性分析

如表2所示.CM與RM的C1、C2均在<0.05水平上與C3呈負相關性顯著,這說明C3減小會引起C1和C2的增加,而C3可能是C1和C2的來源.CM與RM的SUVA254、SUVA280及226～400兩兩呈正相關性極顯著(<0.01),說明HA中一些含有苯環的有機物可能在254nm及280nm處有極強的吸收峰,進一步驗證了堆肥過程中芳香性增加,聚合度升高.此外,CM的SUVA254、SUVA280及226～400均與C1呈正相關性顯著(<0.05),RM的SUVA254、SUVA280及226～400均與C2呈正相關性顯著(<0.05),且相關性強度由大到小依次為226～400>SUVA280> SUVA254,226～400顯示相關性更大的原因可能是該參數為堆肥有機物在226～400nm這一波段的紫外吸收區域積分,它包含了SUVA254及SUVA280的相關信息,雖然這3個參數均可在一定程度上反映堆肥腐熟度,但226～400能較為全面地反映堆肥腐殖化程度的紫外特征參數.在CM中,253/203與以上3個紫外參數呈現出正相關性極顯著(<0.01),卻與C1未達到顯著性水平(>0.05),而在RM中,253/203與以上3個參數均未呈現出顯著性水平(>0.05),卻與C2正相關性顯著(<0.05),表明該參數與SUVA254、SUVA280及226～400相比,不能較好地反映堆肥的腐熟程度.

表2 堆肥HA的熒光組成與光譜特征參數的相關性

注:*,<0.05:相關性顯著;**,<0.01:相關性極顯著.

2.5 堆肥對水稻植株內Cd的積累效果

表3 雞糞堆肥與赤泥堆肥的理化性質

由表3可知,經過堆肥處理后,CM和RM處理中重金屬的總量均未超過有機無機復合肥料(GB/T 18877-2020)[38]的限量標準.

由表4可知,隨著2種堆肥施加劑量增加,土壤pH值逐漸增加.施加雞糞堆肥與赤泥堆肥后顯著降低了土壤中DTPA-Cd含量,土壤中Cd的活性隨著施加劑量的增加而降低.未改良土壤中DTPA-Cd的含量為1.10mg/kg,施加雞糞堆肥與赤泥堆肥后土壤中DTPA-Cd的降低幅度分別為11.92%～20.91%和14.09%～33.59%.施加赤泥堆肥后顯著增加了土壤中有效Si的含量,且隨著施加劑量的增加而增加,增加幅度為49.07%～75.21%.而施加雞糞堆肥后對土壤中有效Si影響不顯著.施加2種堆肥后,與CK相比,水稻糙米中Cd含量均顯著降低,降低幅度為17.97%～58.68%.糙米Cd的含量在0.17～0.42mg/kg之間,水稻糙米Cd含量由大到小為:CK>CM0.5> CM1>CM2>RM0.5>RM1>RM2,其中RM2處理下的糙米Cd含量低于國家《食品安全國家標準食品中污染物限量》中的規定值(0.2mg/kg,GB 2762- 2017)[39].

表4 不同劑量的雞糞堆肥與赤泥堆肥對土壤性質及糙米中Cd含量的影響

注:同列不同小寫字母表示不同處理間存在顯著差異(<0.05,=3).

土壤中有效態Cd與糙米Cd含量的降低,可能是由于堆肥的堿性有效增加了pH值,有利于重金屬氫氧化物復合物沉淀的生成[40].而赤泥中還含有硅酸鹽礦物,SiO32-水解產生的OH-對中和土壤酸性、提高土壤pH值有著至關重要的作用.此外,硅酸鹽礦物中的有效硅可與土壤中移動態Cd2+形成CdSiO3沉淀物,使重金屬沉積在土壤和植物根系表面[41].

同時,因堆肥過程中形成大量腐殖質,腐殖質和土壤中重金屬離子發生螯合與絡合反應[42].腐殖質中的羧基、酚羥基以及羰基等活性功能基團增加,促進腐殖質提供更多可絡合重金屬的吸附點位[43],形成有機金屬配合物.其中,氨基和巰基基團對Cd2+的絡合與羥基對Cd2+的共沉淀均起重要作用.可見,施加堆肥對土壤Cd的生物有效性有抑制作用,對水稻植株內Cd起到有效的阻隔效果,且施加赤泥堆肥效果更為顯著.

3 結論

3.1 雞糞堆肥與赤泥堆肥高溫期均維持5d,已達到無害化衛生要求,且添加赤泥后,提高了堆體高溫期的溫度.2種堆肥的EC較堆肥前均顯著降低,堆肥完成時,RM的EC要顯著高于CM的EC,表明赤泥的添加會增加堆體的EC.雞糞堆肥與赤泥堆肥的GI在堆肥結束時分別達到100.21%和96.44%,說明兩種堆肥產品均沒有植物毒性,且達到腐熟狀態.

3.2 隨著堆肥的進行,2個處理的腐殖酸中類蛋白質等物逐漸轉化為較為穩定的類腐殖質物質,腐殖酸的SUVA254和SUVA280、253/203、226～400在堆肥結束后也均得到提高,說明堆肥的芳香性與腐殖化程度升高,且赤泥的添加會加速堆體的腐殖化進程.

3.3 雞糞堆肥與赤泥堆肥提高了土壤的pH值,顯著降低了土壤中DTPA-Cd的含量,施加2g/kg赤泥堆肥后,土壤中DTPA-Cd的含量降低了33.59%,且顯著增加了土壤中有效Si的含量.施加2種堆肥后,糙米中Cd含量降低幅度為17.97%～58.68%,且施用2g/kg赤泥堆肥時,水稻糙米種Cd的含量降低至0.17mg/kg,并達到中國的食用安全標準.

[1] 薛群虎,陳延偉.廣西平果鋁赤泥綜合利用思路與探索[J]. 輕金屬,2011,(10):11-14.

Xue Q H,Chen Y W,Thought and exploration on the comprehensive utilization of red mud from Guangxi Pingguo aluminium Co. [J]. Light Metals,2011,(10):11-14.

[2] 王清濤,李 森,于華芹,等.利用赤泥制備輕質高強保溫裝飾一體化建筑材料[J]. 硅酸鹽通報,2018,37(4):1393-1398.

Wang Q T,Li S,Yu H Q,et.al.Preparation of light-weiht hight-strength thermal insulation and decoration integration building materials using red mud as raw materials. [J]. Bulletin of the Chinese Ceramic Society,2018,37(4):1393-1398.

[3] Wang Y,Zhang T A,LYU G,et al.Recovery of alkali and alumina from bauxite residue (red mud) and complete reuse of the treated residue [J]. Journal of Cleaner Production,2018,188:456-465.

[4] 李宇慶,陳 玲,仇雁翎,等.上?；瘜W工業區土壤重金屬元素形態分析[J]. 生態環境,2004,13(2):154-155.

Li Y Q,Chen L,Qiu Y L,et al. Speciation of heavy metals in soil from Shanghai Chemical Industry Park [J]. Ecology and Environment,2004,13(2):154-155.

[5] 何增明,劉 強,謝桂先,等.好氧高溫豬糞堆肥中重金屬砷、銅、鋅的形態變化及鈍化劑的影響[J]. 應用生態學報,2010,21(10): 2659-2665.

He Z M,Liu Q,Xie G X,et al. Changes of heavy metals form during aerobic high temperature composting of pig manure and the effects of passivators [J]. Chinese Journal of Applied Ecology,2010,21(10): 2659-2665.

[6] Summers R N,Pech J D. Nutrient and metal content of water,sediment and soils amended with bauxite residue in the catchment of the Peel Inlet and Harvey Estuary,Western Australia [J]. Agriculture Ecosystems & Environment,1997,64(3):219-232.

[7] Yu K,Li S,Sun X,et al. Maintaining the ratio of hydrosoluble carbon and hydrosoluble nitrogen within the optimal range to accelerate green waste composting [J]. Waste Management,2020,105:405-413.

[8] 李文姣,張 麗,劉東方,等.不同鈍化劑對豬糞中重金屬Cu Zn Mn鈍化效果的研究[J]. 農業環境科學學報,2018,37(6):1262-1269.

Li W J,Zhang L,Liu D F,et al,Impact of different passivating agents on heavy metals Cu,Zn and Mn in pig manure [J]. Journal of Agro-Environment Science,2018,37(6):1262-1269.

[9] Chen Z,Fu Q,Cao Y,et al. Effects of lime amendment on the organic substances changes,antibiotics removal,and heavy metals speciation transformation during swine manure composting [J]. Chemosphere,2021,262:128342.

[10] Wang Q,Huang Q,Guo G,et al. Reducing bioavailability of heavy metals in contaminated soil and uptake by maize using organic- inorganic mixed fertilizer [J]. Chemosphere,2020,261(1–4):128122.

[11] Zhang G,Song K,Miao X,et al. Nitrous oxide emissions,ammonia volatilization,and grain-heavy metal levels during the wheat season: Effect of partial organic substitution for chemical fertilizer [J]. Agriculture Ecosystems & Environment,2021,311(129-132):107340.

[12] Hui L,Yan L,Zhou Y,et al. Effects of red mud based passivator on the transformation of Cd fraction in acidic Cd-polluted paddy soil and Cd absorption in rice [J]. Science of the Total Environment,2018,640–641: 736-745.

[13] 楊海君,金紅玉,肖 為,等.香樟樹枝堆肥產物與盾構脫水泥共堆肥的效果[J]. 水土保持通報,2020,40(2):188-192.

Yang H J,Jin H Y,Xiao W,et al. Efficiency of Co-compost of cinnamomum camphora branch compost and shield decement [J]. Bulletin of Soil and Water Conservation,2020,40(2):188-192.

[14] 田 赟,王海燕,孫向陽,等.添加竹酢液和菌劑對園林廢棄物堆肥理化性質的影響[J]. 農業工程學報,2010,26(8):272-278.

Tian Y,Wang H Y,Sun X Y,et al. Effects of bamboo vinegar and bacterial reagent addition on physico-chemical properties of green wastes compost [J]. Transactions of the Chinese Society of Agricultural Engineering,2010,26(8):272-278.

[15] Wu J,Zhao Y,Yu H,et al. Effects of aeration rates on the structural changes in humic substance during co-composting of digestates and chicken manure [J]. The Science of the Total Environment,2019658: 510-520.

[16] Kuwatsuka S,Watanabe A,Itoh K,et al. Comparision of two methods of preparation of humic and fulvic acids,IHSS method and NAGOYA method [J]. Soil Science and Plant Nutrition,1992,38(1):23-30.

[17] 魏自民,席北斗,李鳴曉,等.微生物接種堆肥胡敏酸三維熒光特性研究[J]. 光譜學與光譜分析,2008,28(12):2895-2899.

Wei Z M,Xi B D,Li M X,et al. Study on three-dimensional fluorescence spectroscopy characteristics of humic acid during composting with microbes inoculation [J]. Spectroscopy and Spectral Analysis,2008,28(12):2895-2899.

[18] 李 丹,何小松,高如泰,等.紫外-可見光譜研究堆肥水溶性有機物不同組分演化特征[J]. 中國環境科學,2016,36(11):3412-3421.

Li D,He X S,Gao R T,et al. Evolution based on the spectra of different hydrophilic and hydrophobic components separated from dissolved organic matter (DOM) during compost [J]. China Environmental Science,2016,36(11):3412-3421.

[19] 鮑士旦.土壤農化分析(第三版) [M]. 北京:中國農業出版社,2000.

Bao S D. Soil agrochemical Analysis (3rd edition) [M]. Beijing: China Agriculture Press,2000.

[20] 劉杏芳,杜 華,唐 璜,等.土壤中重金屬元素檢測不同消解方法的比較[J]. 中國口岸科學技術,2021,3(9):90-95.

Liu X F,Du H,Tang H,et al. Comparison of different digestion methods for detection of heavy metal elements in soil [J]. China Port Science and Technology,2021,3(9):90-95.

[21] 甘國娟,劉 妍,朱曉龍,等.3種提取劑對不同類型土壤重金屬的提取效果[J]. 中國農學通報,2013,29(2):148-153.

Gan G J,Liu Y,Zhu X L,et al. The extraction efficiency of three extracting agents for heavy metals in different types of soil [J]. Chinese Agricultural Science Bulletin,2013,29(2):148-153.

[22] 邵 淼,楊淑英,張增強,等.不同處理對高含水率奶牛糞便好氧堆肥的影響 [J]. 農業環境科學學報,2010,29(5):982-989.

Shao M,Yang S Y,Zhang Z Q,et al. Effect of different treatments on composting of high water content dairy manure [J]. Journal of Agro-Environment Science,2010,29(5):982-989.

[23] Wang X,SelvamWong J W C. Influence of lime on struvite formation and nitrogen conservation during food waste composting [J]. Bioresour Technology,2016,217:227-232.

[24] 靳 光,薛艷蓉,淡江華,等.牛糞中添加玉米秸稈對堆肥發酵的影響[J]. 現代畜牧獸醫,2021,(7):15-18.

Jin G,Xue Y R,Dan J H,et al. Effect of adding corn stalks to dairy manure on compost fermentation [J]. Modern Journal of Animal Husbandry and Veterinary Medicine,2021,(7):15-18.

[25] 鮑艷宇,周啟星,顏 麗,等.畜禽糞便堆肥過程中各種氮化合物的動態變化及腐熟度評價指標[J]. 應用生態學報,2008,19(2):374-380.

Bao Y Y,Zhou Q X,Yan L,et al. Dynamic changes of nitrogen forms in livestock manure during composting and relevant evaluation indices of compost maturity [J]. Chinese Journal of Applied Ecology,2008,19(2):374-380.

[26] Pan J,Li R,Zhai L,et al. Influence of palygorskite addition on biosolids composting process enhancement [J]. Journal of Cleaner Production,2019,217:371-379.

[27] 顧文杰,張發寶,徐培智,等.堆肥反應器中硫磺對牛糞好氧堆肥的保氮效果研究[J]. 植物營養與肥料學報,2011,17(1):224-230.

Gu W J,Zhang F B,Xu P Z,et al. Nitrogen conservation by adding sulfur to dairy manure in compost bioreactors [J]. Plant Nutrition and Fertilizer Science,2011,17(1):224-230.

[28] Boehme J R,Coble P G. Characterization of colored dissolved organic matter using high-energy laser fragmentation [J]. Environmental Science & Technology,2000,34(15):3283-3290.

[29] 李曉潔,高紅杰,郭冀峰,等.三維熒光與平行因子研究黑臭河流DOM [J]. 中國環境科學,2018,38(1):311-319.

Li X J,Gao H J,Guo J F,et al. Analyzing DOM in black and odorous water bodies using excitation-emission matrix fluorescence with PARAFAC [J]. China Environmental Science,2018,38(1):311-319.

[30] 楊 超,何小松,高如泰,等.堆肥過程不同分子量水溶性有機物電子轉移能力的演變及影響因素[J]. 分析化學,2017,45(4):579-586.

Yang C,He X S,Gao R T,et al. Effect of compositional and structural evolution of size-fractionated dissolved organic matter on electron transfer capacity during composting [J]. Chinese Journal of Analytical Chemistry,2017,45(4):579-586.

[31] Spierings J,Worms I,Mieville P,et al. Effect of humic substance photoalteration on lead bioavailability to freshwater microalgae [J]. Environmental Science & Technology,2011,45(8):3452-3458.

[32] 鄭 威,周 紅,楊航波,等.海泡石添加對豬糞堆肥腐熟和水溶性有機質的影響[J]. 農業工程學報,2021,37(1):259-266.

Zheng W,Zhou H,Yang H B,et al. Effects of sepiolite addition on pig manure compost maturity and dissolved organic matter [J]. Transactions of the Chinese Society of Agricultural Engineering,2021,37(1):259-266.

[33] Li P,Hur J. Utilization of UV-Vis spectroscopy and related data analyses for dissolved organic matter (DOM) studies: A review [J]. Critical Reviews in Environmental Science & Technology,2017,47(1/6):131-154.

[34] Chin Y P,Aiken G,O'Loughlin E. Molecular weight,polydispersity,and spectroscopic properties of aquatic humic substances [J]. Environmental Science & Technology,1994,28(11):1853-1858.

[35] Peuravuori J,Pihlaja K,Valimaki N. Isolation and characterization of natural organic matter from lake water: Two different adsorption chromatographic methods [J]. Environment International,1997,23(4): 453-464.

[36] Perminova I V,Grechishcheva N Y,Kovalevskii D V,et al. Quantification and prediction of the detoxifying properties of humic substances related to their chemical binding to polycyclic aromatic hydrocarbons [J]. Environmental Science & Technology,2001,35(19): 3841-3848.

[37] 李鳴曉,何小松,劉 駿,等.雞糞堆肥水溶性有機物特征紫外吸收光譜研究[J]. 光譜學與光譜分析,2010,30(11):3081-3085.

Li M X,He X S,Liu J,et al. Study on the characteristic UV absorption parameters of dissolved organic matter extracted from chicken manure during composting [J]. Spectroscopy and Spectral Analysis,2010,30(11):3081-3085.

[38] GB/T 18877-2020 有機無機復混肥料[S].

GB/T 18877-2020 Organic and inorganic compound fertilizer [S].

[39] GB 2762-2017 食品安全國家標準食品中污染物限量 [S].

GB 2762-2017 National food safety standards Limits of contaminants in food [S].

[40] 費宇紅,曹樹堂,張光輝,等.鎘在土壤中吸附與沉淀的特征與界限[J]. 地球?qū)W報,1998,(4):74-79.

Fei Y H,Cao S T,Zhang G H,et al. Characteristics and boundary line between adsorption and precipition of cadmium in soil [J]. Acta Geoscientia Sinica,1998,(4):74-79.

[41] 武成輝,李 亮,雷 暢,等.硅酸鹽鈍化劑在土壤重金屬污染修復中的研究與應用[J]. 土壤,2017,49(3):446-452.

Wu C H,Li L,Lei C,et al. Research and application of Silicate passivation agent in remediation of heavy metal-contaminated soil: A review [J]. Soils,2017,49(3):446-452.

[42] Liang X F,Han J,Xu Y M,et al. Sorption of Cd2+on mercapto and amino functionalized palygorskite [J]. Applied Surface Science,2014,322:194-201.

[43] Baldrian P. Interactions of heavy metals with white-rot fungi [J]. Enzyme & Microbial Technology,2003,32(1):78-91.

Effects of red mud on compost maturity and Cd resistance control of rice.

ZHOU Hong-yan1,CHEN Zhe1,2*,LI Kan-qi1,LENG Wei-gui3,WANG Zong-kang3

(1.College of Environmental Science and Engineering,Guilin University of Technology,Guilin 541004,China；2.Key Laboratory of Ecology and Environmental Protection of Rare and Endangered Plants,Ministry of Education,Guangxi Normal University,Guilin 541004,China；3.Guigang Patan Ecology Co.,LTD.,Guigang 537000,China).,2022,42(8)：3812～3821

Red mud was used as an additive to conduct aerobic composting experiments of chicken manure for evaluating effects of red mud on temperature,pH,electrical conductivity (EC),and seed germination index (GI) during composting. The evolution characteristics of humic acid (HA) components during composting were analyzed by combining three-dimensional fluorescence with ultraviolet-visible light spectrum; and the pot experiments were also conducted to explore the barrier effect of compost products on rice cadmium in the mining soil. The results showed that red mud increased the temperature of the compost during the high temperature period. The EC of both groups decreased significantly after composting,however,the EC of red mud compost (4.29mS/cm) was much higher than that of chicken manure compost (3.59mS/cm).The GI of chicken manure compost and red mud compost increased with composting time by; 100.2% and 96.44%,respectively,at the end of composting,indicating that the products of neither red mud compost nor chicken manure compost exhibited phytotoxicity. The protein-like substances in the HA of the two kinds of composts were converted into relatively stable humus-like substances throughout the composting process. A significant increase in SUVA254,SUVA280,and A226-400of HA indicates the elevated humification degree of compost. In addition,red mud could optimize the humification parameters,implying that the addition of red mud can accelerate the humification process of the heap. In pot experiments,both chicken manure compost and red mud compost increased soil pH and reduced the concentration of DTPA-Cd in soil and total Cd in brown rice. After applying 2g/kg red mud compost,the Cd content in brown rice decreased significantly (by 58.68%) from 0.42mg/kg to 0.17mg/kg after composting. Therefore,red mud can accelerate the composting efficiency to a certain extent. The application of compost products can inhibit the bioavailability of Cd in both soil and rice plants,and an addition of red mud can lead to a higher composting efficiency.

red mud；chicken manure；composting；rice；cadmium pollution；heavy metals

X705

A

1000-6923(2022)08-3812-10

2022-01-24

廣西創新研究團隊項目(2018GXNSFGA281001);廣西科技基地和人才專項(桂科AD19110012);貴港市科技研發項目(貴科攻2021019);桂林市重大科技專項(20190219-3)

* 責任作者,講師,ldchenzhe@qq.com

周紅燕(1997-),女,四川廣安人,桂林理工大學碩士研究生,主要從事固體廢物資源化研究.