雷照源 李團結 崔峰 郭超奇 易瑞強

摘 要：深部厚煤層綜采工作面沿空開采下引發的煤柱動力失穩，是嚴重影響礦井的安全生產條件之一。以陜西某礦區留設35 m段煤柱穩定性為研究對象，通過賦存條件調查、理論分析、數值計算、現場監測等方法，分析區段煤柱在動、靜載荷下的演化特征。研究表明：煤柱在靜載向動載荷的轉化過程中，35 m煤柱內部兩側的應力峰值從2 m遷移至8 m，雙側擾動下的應力明顯高于煤體的抗壓強度;內部的塑性破壞占比從9.52%增加至40%，最終35 m煤柱內部形成“梯型”穩態結構。根據現場煤柱動載荷影響，結合巷道布置方式提出進行分區支護原則。實踐表明：巷道頂板及煤柱幫經歷3種變化的位移特征，在距采空區70～90 m范圍的運動達到極限。因此，35 m煤柱能滿足開采極限條件下的支撐作用，滿足生產的實際需要。關鍵詞：深部厚煤層;動載荷;靜載荷;區段煤柱

中圖分類號：TD 324

文章編號：1672-9315（2022）01-0091-08??????????? 文獻標志碼：A

DOI：10.13800/j.cnki.xakjdxxb.2022.0113開放科學（資源服務）標識碼（OSID）：

Damage evolution analysis of section coal pillar under

dynamic and static load in deep thick coal seam

LEI Zhaoyuan1，2，4，LI Tuanjie4，CUI Feng1，2，3，GUO Chaoqi4，YI Ruiqiang4

（1.College of Energy Science and Engineering，Xi’an University of Science and Technology，Xi’an 710054，China;

2.Key Laboratory of Western Mine Exploitation and Hazard Prevention，Ministry of Education，

Xi’an University of Science and Technology，Xi’an 710054，China;

3.Key Laboratory of Coal Resource Exploration and Comprehensive Utilization，

Ministry of Land and Resources，Xi’an University of Science and Technology，Xi’an 710054，China;

4.Shaanxi Shanmei Huangling Mining（Group）Co.，Ltd.，Huangling 727307，China）Abstract：The dynamic instability of coal pillar caused by gob mining in fully mechanized mining face of deep thick coal seam seriously affects the safety of mine production.

The section coal pillar（35 m） at a coal mine in Shaanxi province is taken as the research object.The research means are applied including occurrence condition investigation，theoretical analysis，numerical calculation and field monitoring to study evolution characteristics of section coal pillar under dynamic and static loads.Research shows that：under different loads，the peak stress on both sides of the 35 m coal pillar moves from 2 m to 8 m，and the stress under bilateral disturbance is obviously higher than the compressive strength of the coal.The proportion of plastic failure inside increases from 9.52% to 40%，and? a trapezoidal structure is formed inside of 35m pillar.According to the different mining influence of roadway in the field，the principle of partition support is proposed.It turns out that roof and coal pillar undergo three kinds of displacement characteristics，and the movement of goaf reaches the limit at 70 to 90 m.Therefore，35m coal pillar can play a good supporting role under the mining limit conditions and meet the production needs.Key words：deep thick coal seam;dynamic load;static load;section coal pillar

0 引 言

深部煤層賦存原巖應力大，厚煤層回采擾動應力及影響范圍大，易導致回采期間面臨礦壓顯現強烈、巷道變形量大等現象的發生[1]。根據煤柱作用不同，主要分為4類[2]。區段煤柱作為工作面形成的基礎，合理的煤柱尺寸在其內部彈性核的作用下起到保護巷道安全的作用。巷道成型及回采過程中，煤柱內部應力釋放分別呈現緩慢釋放和快速釋放2種不同模式，深部厚煤層開采進一步導致煤柱劇烈變形，給災害防治帶來的挑戰。近年來眾多學者充分考慮地質構造、開采時空關系等影響因素，分析了地表與采動的關系[3-5]。隨著煤柱型動力災害在采動下發生，通過多手段相結合模式，針對“一礦一特色”提出了與之相適應的煤柱監控檢測技術[6-9]。宋錄生等提出并建立了立“頂板-煤層”結構體模型，通過對4種不同模型的沖擊傾向性試驗，得出“頂板-煤層”結構體沖擊傾向性高于純煤層或巖層測定結果[10]。陳紹杰等對不同高比的5組頂板砂巖-煤柱結構體進行單軸壓縮試驗，得出不同的3種結論和砂巖破壞的動態過程[11]。祁和剛等針對深部高應力區段煤柱留設合理性，開展了并提出了“一高一低”的高應力區段煤柱綜合卸荷技術的研究[12]。付玉凱等在分析煤柱留巷圍巖破壞機制的基礎上，提出深部煤柱留巷“卸-支-注”協同控制原理，術有效改善了煤柱留巷的圍巖力學屬性和應力狀態[13]。王濤等分析了臨空煤柱巷道側沖擊地壓的成因和受夾持煤體的沖擊失穩過程，得出了斷頂卸壓爆破可以有效切斷堅硬懸板對煤柱的應力傳遞[14]。伍永平等基于大傾角煤層長壁工作面“R-S-F”系統，研究了區段煤柱的應力分布規律和失穩破壞準則，最終確定了區段煤柱寬度k滿足kZHo7ROntxU6O+CnUVXU1+oTLFKUt/OQ0u8RGzfWuhBeVk=