王 陽，王朝元，李保明

?

蛋雞舍冬季CO2濃度控制標準與最小通風量確定

王 陽1,2，王朝元1,3，李保明1,3※

（1. 中國農業大學農業部設施農業工程重點實驗室，北京 100083；2. 中國農業大學水利與土木工程學院，北京 100083；3. 北京市畜禽健康養殖環境工程技術研究中心，北京 100083）

中國現行的蛋雞舍內CO2濃度控制的農業行業標準為1 500 mg/m3，主要適用于傳統的刮板式清糞雞舍。目前新建、改建雞舍都采用傳送帶清糞方式，雞舍內的相對濕度和氨氣等有害氣體濃度均明顯減少，其冬季最小通風量和舍內CO2濃度參數標準均有待重新研究。該文通過總結分析國內外相關學者對不同清糞方式蛋雞舍內NH3、CO2濃度的測試數據，提出傳送帶清糞蛋雞舍內CO2濃度取值建議，并根據CO2濃度平衡原理，提出該類蛋雞舍冬季最小通風量的取值建議。結果表明：傳送帶清糞蛋雞舍內CO2濃度參數控制標準建議可取5 000 mg/m3；蛋雞舍冬季連續通風最小通風量為0.40～0.50 m3/（h·kg）。該研究為中國新建、改建傳送帶清糞模式蛋雞舍CO2濃度參數標準的取值以及調控蛋雞舍冬季通風與保溫矛盾等問題提供了參考依據。

設施；環境控制；二氧化碳濃度；蛋雞舍；清糞方式；最小通風量

0 引 言

冬季蛋雞舍通風量影響舍內溫度穩定性和空氣質量，進而影響蛋雞的健康和生產性能[1-3]。冬季低溫氣候蛋雞舍通風換氣所需要的通風量，主要為排除蛋雞舍內的污濁空氣，供給蛋雞足夠的氧氣。蛋雞舍冬季最小通風量以CO2平衡原理設計計算，CO2的取值大小決定了雞舍的最小通風量和雞舍的通風耗熱量。依據最小通風量和舍內最低氣溫要求來設計雞舍圍護結構的保溫性能，才能協調好保溫與通風矛盾問題[3]。國外學者對用CO2濃度指標確定畜禽舍冬季最小通風量進行了大量的研究[4-6]，Pedersen等[6]分析了熱、濕和CO2濃度平衡3種通風量計算方法，表明CO2平衡確定的通風量與濕度平衡計算值之間的相關系數為0.95。中國蛋雞舍用CO2濃度平衡確定冬季通風量的研究報道甚少，主要是測試分析了蛋雞舍內CO2濃度的分布規律[7]。

中國傳統蛋雞舍主要是刮板式清糞系統，清糞周期較長，且存在飲水器漏水、清糞不徹底等問題，易造成雞糞發酵，導致舍內濕度、CO2、NH3濃度較高，蛋雞舍內CO2濃度與NH3濃度顯著正相關[8]，為保證舍內NH3濃度不超標（<15 mg/m3），不影響蛋雞的健康和生產性能，中國畜禽場環境質量標準[9]（NY/T 388-1999）規定蛋雞舍內CO2質量濃度環境衛生指標上限為1 500 mg/m3。近年來蛋雞養殖設備及環境調控技術發展迅速，蛋雞舍普遍采用傳送帶清糞且乳頭式飲水器質量提高，舍內清糞及時、通風效率高，雞舍清糞不徹底、雞糞發酵等一般不發生，舍內濕度和NH3濃度明顯減小[10]，中國適用于刮板清糞方式的蛋雞舍內CO2濃度控制標準為保證舍內NH3濃度不超標，但對傳送帶清糞蛋雞舍內NH3濃度較低環境條件下CO2濃度現行標準已明顯偏低。本文通過總結國內外不同清糞方式蛋雞舍內NH3、CO2濃度測試數據結合不同國家蛋雞舍內CO2濃度的控制標準，提出傳送帶清糞蛋雞舍內CO2濃度參數調整建議，并根據CO2濃度平衡原理，確定蛋雞舍冬季最小通風量，為解決北方寒冷地區蛋雞舍保溫與通風的矛盾提供依據。

1 蛋雞舍內CO2濃度參數取值標準分析

蛋雞舍通風換氣是調節舍內空氣環境的最主要方式，舍內空氣質量影響蛋雞的健康及生產性能[10-11]，蛋雞舍內CO2濃度代表舍內空氣的污濁程度，而雞舍的有害氣體產生主要來源于雞糞，近年來傳送帶清糞技術的發展，實現了“糞不落地”即可每天及時傳送到舍外，顯著改善了舍內的空氣質量。通過總結國內外學者對不同清糞方式蛋雞舍內NH3、CO2濃度等進行的大量試驗研究（見表1）[12-22]可知：蛋雞舍內CO2濃度與NH3濃度顯著相關，傳送帶清糞蛋雞舍內NH3濃度比刮板清糞雞舍明顯降低，合理組織通風下舍內CO2質量濃度低于5 000 mg/m3時，舍內NH3質量濃度低于15 mg/m3。Liang等[13]通過對高床、傳送帶清糞蛋雞舍內NH3濃度試驗研究，舍內NH3濃度隨舍外溫度降低、通風量的減小而升高，且傳送帶清糞周期影響舍內NH3濃度含量；為研究蛋雞舍內有害氣體濃度相互關系以及對蛋雞健康、生產性能的影響，Kocaman等[8]對288只24周齡的蛋雞，連續2個月試驗研究，結果表明蛋雞舍內CO2濃度與NH3濃度顯著正相關（<0.01，=0.86）。

表1 蛋雞舍內NH3、CO2濃度部分?jǐn)?shù)據總結表

Ni等[14]進行連續兩年試驗研究2種不同清糞蛋雞舍內NH3、CO2等有害氣體濃度之間的變化規律，發現傳統高床清糞、傳送帶清糞蛋雞舍內NH3、CO2濃度變化趨勢一致，與蛋雞通風量顯著負相關，舍內NH3、CO2濃度同升同減，且舍內CO2質量濃度低于5 000 mg/m3時，舍內NH3質量濃度低于15 mg/m3，試驗結果顯示傳送帶清糞兩棟蛋雞舍內平均CO2質量濃度分別為4 508.04、4 488.39 mg/m3，NH3質量濃度分別為10.09、9.79 mg/m3；Chai等[21]對蛋雞舍內不同測點研究表明NH3質量濃度為8.65、9.11、7.51、7.44 mg/m3，CO2質量濃度5 427.32、5 338.92、5 191.61、5 189.64 mg/m3；Lin等[15]研究高床清糞蛋雞舍、Alberdi等[16]模擬研究富集籠養傳送帶清糞蛋雞舍、Zhao等[17-19]對比研究傳統籠養、棲架飼養、富集籠養蛋雞舍（<0.05），舍內NH3、CO2濃度變化規律驗證了Kocaman[8]、Ni[14]等研究結論：蛋雞舍內CO2濃度與NH3濃度之間顯著正相關，傳送帶清糞蛋雞舍內NH3濃度較低，且舍內CO2質量濃度低于5 000 mg/m3時，合理組織通風舍內NH3質量濃度低于15 mg/m3。

國外學者Kocaman等[8]對蛋雞舍內影響蛋雞生產性能因素的研究分析表明蛋雞舍內CO2質量濃度小于6 187 mg/m3、NH3質量濃度小于15 mg/m3，蛋雞生產性能、健康、免疫力不受影響，驗證了學者Ellen等[23-24]對舍內CO2濃度、NH3濃度對蛋雞生產性能、健康等研究結論；國內學者施正香等[25]對華北地區商品蛋雞舍冬季環境試驗研究表明舍內CO2質量濃度小于5 000 mg/m3，對蛋雞健康及生產性能基本沒有影響；吳鵬威等[26]研究表明冬季傳送帶清糞蛋雞舍進風口、中間、出風口位置CO2質量濃度分別為5 700、5 798、5 983 mg/m3時，蛋雞舍進風口、中間、出風口位置蛋雞產蛋率無顯著變化；國內學者研究[27]表明蛋雞舍內CO2質量濃度為7 548～11 323 mg/m3時，蛋雞產蛋率下降、蛋殼變薄、蛋質量變??；據試驗報道[28]：蛋雞舍內CO2質量濃度為10 312～11 963 mg/m3時，雛雞出現輕微痛苦狀。

不同國家蛋雞舍內允許的CO2濃度標準不同，CIGR[30]（international commission of agricultural engineering）、OSHA[17]（occupational safety and health administration）規定的蛋雞舍CO2質量濃度分別為5 000、8 000 mg/m3，其他國家傳送帶清糞蛋雞舍內CO2濃度標準見下表2。中國1999年制定的蛋雞舍內CO2濃度標準[9]，適用于NH3濃度較高的傳統刮板清糞蛋雞舍，隨著環境調控技術與設備的改進，蛋雞舍內有害氣體濃度及通風效率也發生了相應的改變。根據國內外NH3濃度、CO2濃度研究數據、行業標準以及對蛋雞健康、生產性能的研究[19-29]可知，中國傳送帶清糞蛋雞舍內CO2質量濃度參數標準提高到5000 mg/m3左右，合理的通風組織下蛋雞舍內NH3質量濃度基本不會超過15 mg/m3，對蛋雞健康以及生產性能基本沒有影響。

表2 部分國家傳送帶清糞蛋雞舍CO2質量濃度標準[29]

2 蛋雞舍冬季最小通風量的確定

根據舍內CO2濃度平衡原理[20]，雞舍通風量的計算公式（1）為

式中為冬季雞舍通風量，m3/h；為舍內蛋雞只數，只；為每只蛋雞的CO2產量，L/(h·只)；1為蛋雞舍內空氣中CO2的濃度標準，L/m3；2為舍外空氣中CO2含量，0.3 L/m3。

冬季蛋雞舍的適宜溫度[28]為13～24 ℃，蛋雞開產后質量變化波動不大，蛋雞質量約為1.3～1.8 kg，蛋雞舍CO2主要源自蛋雞的呼吸代謝以及糞便，Li等[32]研究表明對蛋雞舍通風量的研究時糞尿產生CO2量可忽略不計，CIGR[31]估算各種畜禽每產熱單位（hpu，20 ℃時1 000 W總產熱量稱為1個產熱單位）的平均CO2產量為0.185 m3/h。根據CIGR[31]規定的蛋雞呼吸產生CO2量、產熱量計算式及修正（CIGR中修正公式（23）），當?shù)半u舍內CO2濃度標準為5 000 mg/m3時，得出維持舍內不同溫度，傳送帶清糞蛋雞舍冬季最小通風量計算式（2），維持蛋雞舍內溫度下限為13 ℃[27-28]，傳送帶清糞蛋雞舍冬季最小通風量為0.40～0.50 m3/(h·kg)

式中為最小通風量，m3/(h·kg)；為產蛋性能，=0.05 kg/d；為每只蛋雞的質量，kg/只；為冬季舍內計算溫度，℃。

3 蛋雞舍冬季通風量對保溫影響

國外學者Li等[32-36]都對蛋雞舍冬季最小通風量進行了研究，研究數據表明：蛋雞質量為1.5 kg左右，傳送帶清糞蛋雞舍內冬季最小通風量約為0.28～0.54 m3/(h·kg)；中國[7,25]傳送帶清糞蛋雞舍冬季最小通風量約為0.87～1.0 m3/(h·kg)。本研究通過CO2濃度平衡原理確定的蛋雞舍冬季最小通風量約為0.40～0.50 m3/(h·kg)，與國外蛋雞舍冬季最小通風量基本一致，但明顯小于國內蛋雞冬季最小通風量，完善修訂傳送帶清糞蛋雞舍內CO2濃度，合理組織蛋雞舍內通風，才能有效解決雞舍保溫與通風矛盾。

中國蛋雞舍冬季最小通風量一般采用傳統經驗值、推薦值等，蛋雞舍冬季最小通風量較大，冬季一般采用間歇通風解決通風與保溫的矛盾，間歇通風造成舍內溫差和溫度波動大，影響蛋雞生產性能與健康，蛋雞舍內CO2濃度平衡確定的傳送帶清糞蛋雞舍冬季最小通風量較小可保持蛋雞舍連續通風，維持蛋雞舍內溫度穩定，舍內CO2濃度、NH3濃度不超標，可以降低蛋雞舍冬季保溫成本，協調蛋雞舍冬季通風與保溫的矛盾。

4 結 論

1）雞舍的清糞方式是影響蛋雞舍內空氣環境質量的關鍵因素。傳統刮板清糞方式蛋雞舍內NH3質量濃度普遍較高，對于改建、新建蛋雞舍建議采用傳送帶清糞方式，利于減少雞舍冬季通風換氣量、提高舍內溫度，解決雞舍保溫與通風矛盾。

2）中國1999年制定的農業行業標準的蛋雞舍內CO2質量濃度為1 500mg/m3，適用于傳統高床定期清糞、刮板清糞蛋雞舍；對新的傳送帶清糞蛋雞舍內CO2質量濃度控制標準建議提高到5 000 mg/m3。

3）蛋雞舍內CO2質量濃度平衡確定的傳送帶清糞蛋雞舍冬季最小通風量為0.40～0.50 m3/(h·kg)。雞舍圍護結構的保溫性能設計應維持蛋雞舍內溫度下限為13 ℃，保持雞舍連續通風，舍內污染物濃度不超標，以滿足雞舍冬季通風與保溫的需要。

[1] Al-Saffar A A, Rose S P. Ambient temperature and the egg laying characteristics of laying fowl[J]. World’s Poultry Science Journal, 2002, 58(3): 317－331.

[2] Zhao Yang, Xin Hongwei, Shepherd Timothy A, et al. Modelling ventilation rate, balance temperature and supplemental heat need in alternative vs. conventional laying-hen housing systems[J]. Biosystems Engineering, 2013, 115(3): 311－323.

[3] 汪靖，江曉明，李輝. 不同季節種雞舍通風系統的調控[J]. 中國家禽，2016(1)：71－72.

[4] Van Ouverkerk E N J, Pedersen S?ren. Application of the carbon dioxide mass balance method to evaluate ventilation rates in livestock buildings[J]. Proc Xii Cigr'94, Italy, 1994.

[5] Koerkamp P W G G, Metz J H M, Uenk G H, et al. Concentrations and emissions of ammonia in livestock buildings in Northern Europe[J]. Journal of Agricultural Engineering Research, 1998, 70: 79－95.

[6] Pedersen S?ren, Takai Hisamitsu, Johnsen Jan Ove, et al. A comparison of three balance methods for calculating ventilation rates in livestock buildings[J]. Journal of Agricultural Engineering Research, 1998, 70(1): 25－37.

[7] 俞宏軍，李保明，施正香，等. 北京密閉式商品蛋雞舍冬季環境研究（初報）[J]. 農業工程學報，1997，13(5)：68－72.

Yu Hongjun, Li Baoming, Shi Zhengxiang, et al. Winter environment analysising on enclosed commercial layer housing in Beiing[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 1997, 13(5): 68－72. (in Chinese with English abstract)

[8] Kocaman Bahar, Esenbuga Nurinisa, Yildiz Ahmet, et al. Effect of environmental conditions in poultry houses on the performance of laying hens[J]. International Journal of Poultry Science, 2006, 5(1): 26－30.

[9] 畜禽場環境質量標準：NY/ T388-1999[S]. 1999.

[10] 程龍梅，吳銀寶，王燕，等. 清糞方式對蛋雞舍內空氣環境質量及糞便理化性質的影響[J]. 中國家禽，2015(18)：22－27.

[11] Green Angela R, Wesley Irene, Trampel Darrell W, et al. Air

quality and hen health status in three types of commercial laying hen houses:[C]//American Society of Agricultural and Biological Engineers: 2007 ASAE Annual Meeting, 2007.

[12] McQuitty J B, Feddes J J R, Leonard J J. Air quality in commercial laying barns[J]. Canadian Agricultural Engineering, 1985, 27(2): 13－19.

[13] Liang Yi, Xin Hongwei, Wheeler E F, et al. Ammonia emissions from US laying hen houses in Iowa and Pennsylvania[J]. Transactions of the ASAE, 2005, 48(5): 1927－1941.

[14] Ni Ji-Qin, Chai Lilong, Chen Lide, et al. Characteristics of ammonia, hydrogen sulfide, carbon dioxide, and particulate matter concentrations in high-rise and manure-belt layer hen houses[J]. Atmospheric Environment, 2012, 57: 165－174.

[15] Lin X J, Cortus E L, Zhang R, et al. Ammonia, hydrogen sulfide, carbon dioxide and particulate matter emissions from California high-rise layer houses[J]. Atmospheric Environment, 2012, 46: 81－91.

[16] Alberdi Oier, Arriaga Haritz, Calvet Salvador, et al. Ammonia and greenhouse gas emissions from an enriched cage laying hen facility[J]. Biosystems Engineering, 2016, 144: 1－12.

[17] Zhao Yang, Shepherd Timothy A, Li Hong, et al. Environmental assessment of three egg production systems-Part I: Monitoring system and indoor air quality[J]. Poultry Science, 2015, 94(3): 518－533.

[18] Shepherd Timothy A, Zhao Yang, Li Hong, et al. Environmental assessment of three egg production systems: Part II. Ammonia, greenhouse gas, and particulate matter emissions[J]. Poultry science, 2015, 94(3): 534－543.

[19] Zhao Yang, Shepherd Timothy A, Xin Hongwei, et al. Concentrations of ammonia, greenhouse gases and particulate matters in conventional cage, aviary, and enriched colony laying-hen houses[C]//American Society of Agricultural and Biological Engineers: 2014 Montreal, Quebec Canada July 13-July 16, 2014, 2014

[20] Xin H, Gates R S, Green A R, et al. Environmental impacts and sustainability of egg production systems[J]. Poultry Science, 2011, 90(1): 263－277.

[21] Chai Li-Long, Ni Ji-Qin, Chen Yan, et al. Assessment of long-term gas sampling design at two commercial manure-belt layer barns[J]. Journal of the Air & Waste Management Association, 2010, 60(6): 702－710.

[22] Green Angela R, Xin Hongwei. Effects of stocking density and group size on heat and moisture production of laying hens under thermoneutral and heat-challenging conditions[J]. Transactions of the ASABE, 2009, 52(6): 2027.

[23] Ellen H H, Bottcher R W, Von Wachenfelt E, et al. Dust levels and control methods in poultry houses[J]. Journal of Agricultural Safety and Health, 2000, 6(4): 275.

[24] Kocaman Bahar, Yaganoglu A Vahap, Yanar Mete. Combination of fan ventilation system and spraying of oil-water mixture on the levels of dust and gases in caged layer facilities in Eastern Turkey[J]. Journal of Applied Animal Research, 2005, 27(2): 109－111.

[25] 施正香，俞宏軍，李保明，等. 華北地區商品蛋雞舍冬季環境管理[J]. 中國農業大學學報，1997，2(6)：71－75.

Shi Zhengxiang, Wen Shuxiang. Environmental management on commercial layer housing during winter in North China[J]. Journal of China Agricultural University, 1997, 2(6): 71－75. (in Chinese with English abstract)

[26] 吳鵬威. 半開放式雞舍不同季節環境參數變化規律及其對蛋雞生產性能影響的研究[D]. 保定：河北農業大學，2013.

Wu Pengwei. Research About Variation of Semi-open Sheds in Different Seasons on Environmental Parameters and its Effect the Performance of Laying Hens[D]. Baoding: Hebei Agricultural University, 2013. (in Chinese with English abstract)

[27] 馬承偉，苗香雯. 農業生物環境工程[M]. 中國農業出版社，2005.

[28] 董紅敏，陶秀萍.畜禽養殖環境控制與通風降溫[M]. 北京：中國農業出版社，2007.

[29] Pedersen S?ren, Blanes-Vidal Victoria, Joergensen H, et al. Carbon dioxide production in animal houses: A literature review[J]. Agricultural Engineering International: CIGR Journal, 2008.

[30] Pedersen S, S?llvik K. Heat and moisture production at animal and house levels. 4th Report of, Working Group on Climatization of Animal Houses[J]. CIGR Horsens, 2002.

[31] Pedersen S, S?llvik K. Climatization of Animal Houses-Heat and Moisture production at animal and house level 4 th report of CIGR working group[J]. Research Centre Bygholm, Danish Insitute of Agricultural Sciences, Horsens, Demark, 2002.

[32] Li Hong, Xin Hongwei, Liang Yi, et al. Comparison of direct vs. indirect ventilation rate determinations in layer barns using manure belts[J]. Transactions of the ASAE, 2005, 48(1): 367－372.

[33] Li H, Liang Y, Xin H. Determination of ventilation rates for a manure-belt laying hen house using CO2balance[J]. Journal Agricultural & Food Chemistry, 2005, 95(1): 378－385.

[34] Chai L L, Ni J Q, Diehl C A, et al. Ventilation rates in large commercial layer hen houses with two-year continuous monitoring[J]. British Poultry Science, 2012, 53(1): 19－31.

[35] Feddes J J R, DeShazer J A. Feed consumption as a parameter for establishing minimum ventilation rates[J]. Transactions of the ASAE, 1991, 31(2): 571－575.

[36] Lim T T, Heber A J, Ni J Q. Air quality measurement at a laying hen house[C]//Ventilation Airflow Measurement: ASAE Meeting Paper, 2003.

Determination of carbon dioxide concentration standards and minimum ventilation rates of layer house in winter

Wang Yang1,2, Wang Chaoyuan1,3, Li Baoming1,3※

(1.,,100083,; 2.100083,;3.100083,)

The CO2concentration is required to be below 1500 mg/m3(Environmental Quality Standards for the Livestock and Poultry Farm of China, published in 1999) in layer hen houses where the manure is disposed by powered scraper, the litters generally need to remind and the drinking device has water leak. Consequently, moisture and NH3levels in such barns are much high. Also, air temperature is much lower in winter, because the minimum ventilation rate is large in winter. However, the manure is cleaned daily in new poultry house with manure convey belt. Meanwhile, the aerial pollutants (CO2and NH3) are reduced and the relative humidity is decreased. Indoor air quality in this kind of poultry house is dramatically improved. A new standard of CO2concentration and the minimum ventilation rate of layer house with manure convey belt should be reconsidered. Determining the CO2concentration standards for the manure convey belt in layer hen houses is needed. The objectives of this work were to draw a conclusion about the CO2concentration levels and use it as a reference to calculate the minimum ventilation rate in winter. This review summarized the recent measurements of the emission rates of aerial NH3and the CO2concentrations in poultry houses in which the laying hens were kept in cages. The relationship between CO2and NH3was also described based on the data got in the poultry houses with different manure removing way from the domestic and foreign study. In addition, the minimum ventilation rate is important for ensuring the ideal air quality in poultry house in winter. The optimum ventilation is one of the factors affecting poultry production and energy consumption. Considering the mass conservation under steady-state conditions in the layer hen building, there are 2 main sources of CO2in poultry house, and most of the CO2is produced by respiration processes of layer hens, if neglecting the amount of CO2emitted from manure. The minimum temperature value for layer houses was 13 ℃ in this study. The following conclusions were drawn in this study: 1) There was a positive and significant correlation between CO2and NH3concentration in layer houses based on analyzing the data of previous researches. The standards of CO2concentration and NH3concentration were suggested to be 5000 mg/m3and less than 15 mg/m3respectively in the layer hen houses with manure convey belt. This condition would not reduce the hen’s performance and defenses. Primary CO2concentration standards persisted when the feces were scraped by powered scraper to a cross conveyor at the end of the barn; 2) Average NH3concentrations in the layer house with manure convey belt was largely less than the traditional house with the scraper. Therefore, rebuilding new layer hen’s building equipped with the manure convey belt is crucial not only for indoor environment, but also for ventilation system; 3) Ventilation rate was calculated using the rate of laying hen in winter based on CO2mass balances from the literature. The constantly minimum ventilation rates were 0.40-0.50 m3/(h·kg) for the layer houses with manure convey belt. The new standards of CO2concentration and ventilation rate were beneficial for improving indoor environment control and ventilation energy efficiency, and saving constructional costs. Furthermore, the results of this paper provide the reference for solving the contradiction between ventilation and insulation system in layer house. Also, it can improve the versatility of poultry environment and provide the support for emission studies using the new standard of the CO2to evaluate the poultry building environment.

facilities; environmental control; carbon dioxide; layer house; manure belt; minimum ventilation rates

10.11975/j.issn.1002-6819.2017.02.033

S831.9; X512

A

1002-6819(2017)-02-0240-05

2016-04-22

2016-11-10

國家863課題任務（2013AA10230602）；國家蛋雞產業技術體系（CARS-41）；中央高?；究蒲袠I(yè)務費專項資金資助（2015SYL001)。

王陽，女，博士生，山東濰坊人，研究方向?yàn)樾笄萁】淡h(huán)境及其控制技術。北京中國農業大學水利與土木工程學院 100083。 Email：wangyang512@cau.edu.cn

李保明，男，教授，浙江縉云人，博士生導師，主要從事畜禽設施養殖工藝與環境研究。北京中國農業大學水利與土木工程學院 100083。Email：libm@cau.edu.cn

王 陽，王朝元，李保明. 蛋雞舍冬季CO2濃度控制標準與最小通風量確定[J]. 農業工程學報，2017，33(2)：240－244. doi：10.11975/j.issn.1002-6819.2017.02.033 http://www.tcsae.org

Wang Yang, Wang Chaoyuan, Li Baoming. Determination of carbon dioxide concentration standards and minimum ventilation rates of layer house in winter[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2017, 33(2): 240－244. (in Chinese with English abstract) doi：10.11975/j.issn.1002-6819.2017.02.033 http://www.tcsae.org